Calibrate the battery cell

First of all, the test voltage to zero, the machine can not start naturally, can not use power when charging (the battery light does not shine).
Disassemble the battery, more or less talk about the situation inside the battery.
Battery in a total of 9 can be placed 18 millimeters in diameter, length 65 mm core CGH18650 models the location of lithium batteries, Panasonic's 22 batteries in parallel, three groups of series (OK, then my new Dell Inspiron 6000 Battery, the same, it appears that is 6), there is a very fine control with a single chip - the protection of the circuit, the circuit to the computer a total of five output contacts, respectively, are negative, the clock and data.
First of all, check the sticky in the battery temperature detection probe (temperature resistance), and temperature protection insurance, are also normal. Test-retest the battery voltage of each group, in which two sets of battery voltage of 3.8V, normal; a Dell Latitude D820 Battery voltage of 0V, appear to have lapsed. The total battery voltage of 7.6V, then the failure of the battery pack has not yet open, then measuring the internal resistance was very small, almost in a state short-circuit.
First of all, failure to deal with Dell Inspiron 6400 Battery, battery repair based on previous experience, the failure of the battery may not be completely damaged, can be activated through a number of methods, in particular the performance of state for the short-circuit the Dell XPS M140 Battery. The voltage of the battery to 0 with one end connected to the circuit board off line to avoid damage to circuit boards in operation. Open-circuit battery voltage after the re-survey, is still 0V, ruled out the possibility of short-circuit boards.
For short-circuit the battery failure, the method is more effective high-voltage electric current moment method, using the old Sony power supply (my back-up power), 16V maximum 3A output string on the multimeter (a tributary of the current file 20A), first negative power supply Even with the battery anode, and cathode power multimeter then red table pen, table pen with black multimeter battery cathode touch, speed, faster as far as possible, the former two degrees to see the multimeter has reached close to the 2A (moment) and the third on only 0.4 A about an immediate stop, measure the Dell XPS M1530 Battery voltage has been restored to about 3V, the internal battery short-circuit that point has been an instant high-current boil (If you do not damage the battery to stop immediately, even if so, battery life and capacity have been the impact, if conditional, or recommend replacement, but if the replacement, then try to replace the entire battery pack are). However, the Dell Inspiron 1545 Battery need to be a separate charge (if the battery charge of the whole group, this will result in the other two groups had mesenchymal cells), plug in the charger to start charging ammeter to monitor during the charge current to 500mA or so, current for the 3.6AH battery pack is small, but the charger is the charge current is limited and a small current to the HP pavilion dv9000 Battery charge is good for the resumption. After about six hours, the charger showed the battery is already full, continue to re-charge for about two hours, remove the battery, measure voltage has reached 4.2V, with bright halogen bulb in the flashlight (3V, 500mA) to discharge its , bulb sharp discharge current of 700mA, the battery pack that has been basically restored, continue to discharge until the battery voltage down to 3.8V, the purpose of the two groups with the same battery voltage, charging time together so as not to overcharge the Back to the whole battery pack battery circuit welding.
Since the HP pavilion dv8000 Battery voltage while the circuit board there is no output, then, surely have damaged circuit boards, after observation, negative input circuit board (take battery) output (then output contact) is directly connected, and the positive input and output of by a high-power thyristor control, the thyristor remains cut-off state, that is, the control circuit has not been output control signals to the SCR control terminal, or simply the SCR has been destroyed. (Measured after the control signals that I did not) because I do not have the ability to repair single-chip microcomputer. IBM to take into account the protection of the BB more perfect, is about to run out of battery power will automatically shut down when, this battery is intended to be used for entertainment, therefore, need not be too concerned about, so I decided to shake the hp battery protection circuit, directly depend on BB's protection circuit. SCR is in the input and output pin (that is, cathode circuit board input and output pin) between the solder on a small 2A fuse, fuse 2A select the reason is based on current usage, the largest in the computer power consumption , the current does not exceed 1.9A, 2A capacity sufficient unusual circumstances (for example, short-circuit accident) but also to ensure that the fuse of the time, but also play a role in protection.
In fact, directly to the SCR control terminal so that it can also be a high turn-on, but taking into account the current the battery must be a reason to burn, and the reasons for the identification of protective measures taken before or better in order to avoid greater loss.
Well, the battery power has been the first non-stick, and on the machine to try it! Normal boot, plug in the power immediately after the charge on the flashing lights are up, the way when charging the Sony VGP-BPL9 Battery with a random look at battery information management software, was also displayed, the battery circuit board This shows that the single chip is still working.
Batteries Sony VGP-BPS4 Battery is a Panasonic, the time the factory in June 2000, the first time in October 2000, the design capacity of 38.88Wh, the current capacity 38.88Wh, is charging cycle: 0 times.
Oh, do not know how to engage in, the Sony VAIO VGN-FZ Battery may be burned when burning confused, even cycles to the zero, Now it maybe a new battery.

View this post on my blog: http://www.choosehpcomputer.com/hp-computer-deals/calibrate-the-battery-cell.html